COMPLETE IGNITION SYSTEMS
Capacitive Discharge Ignitions systems includes high voltage module, spark coil, shielded spark plug lead, battery lead and pulse switch lead with Deans plug. 
Assembled in a heavy duty aluminum case, these systems are for engines that are already set up with a hall effect triggered ignition system.
They do not include switch harness, spark plug, pulse switch, magnet, battery or Syncro Spark computer timing control. 
All systems require a full time on board battery pack, 4.8 to 6 volts with 700 MAH or larger capacity.
Let us know when you place your order if you are going to use LiPoly batteries. We can adjust the C.H. system so you will not need a regulator.
Add $29.00 to the price of any system for built in Computer Timing Control.
Our new stainless steel cap system will fit the short 3/4hex 14mm spark plug.  Such as the Champion RCJ 7 Y or NGK BPMR 6A.
It will not fit the Champion RDJ6 J or NGK BPMR6F.
Part numbers 25-130 below are ignition systems only. Order pulse kits, timing kits, etc. separately. If in doubt, call us.

click on the camera pic for photos, instructions and/or information

  SINGLE CYLINDER IGNITION SYSTEMS
     26. Single ignition l4mm spark plug, rubber boot  ......................................................................................... $79.95
     27. Single ignition 14mm spark plug, with RCEXL metal cap and silicone boot............................................ $109.95     

  TWIN CYLINDER IGNITION SYSTEMS
     29.  Twin ignition 14mm spark plugs with rubber boots ............................................................................... $109.95
     30. Twin ignition 14mm spark plugs with RCEXL metal cap and silicone boot.............................................. $129.95
     130. Part #30 above with built in Syncro Spark .......................................................................................... $159.95

      SEE ZENOAH, FUJI, 3W, EVO 160, DA BELOW
      CALL ABOUT OTHER TWIN CYL IGNITIONS .
                         
  CHXL IGNITION SYSTEMS

      We put each CHXL ignition through a series of tests to assure that it meets our specs.
      All CHXL systems include computer timing control and stainless steel spark plug covers.
     
      227. CHXL single system for 10mm NGK CM-6 or Denso U20M-U plugs ................................................ $79.95
      228. CHXL single system for 14mm NGK BPMR6F or Champion RDJ6 or 7J,
             5/8 hex, taper seat plugs........................................................................................................................ $79.95
      229. CHXL single system for 14mm NGK BPMR6A, BMR6A or Bosch R-10, 3/4 hex, gasketed plugs ..... $79.95
      241. CHXL twin system for 10mm NGK CM-6 or Denso U20M-U plugs .................................................. $99.95
      242. CHXL twin system for 14mm X 5/8" NGK BPMR6F or Champion RDJ6 or 7J,
              taper seat plugs.................................................................................................................................... $99.95
      243. CHXL twin system for 14mm X 3/4" NGK BPMR6A, BMR6A or Bosch R-10, with gasket
              (will not fit Champion RCJnY series) ................................................................................................... $99.95
              
      
     
       We have CHXL Ignitions for many other engines. Call to see if we have one for your engine.
       We also have replacement CHXL Ignitions and timing kits for most of the Chinese engines.
       These run from $99.00 to $130.00 depending on the number of machined parts are required.

 

  ZENOAH IGNITION PACKGES
          Includes lightweight aluminum flywheel timing
          bracket, High voltage circuit and Timing Board,
          and Heavy duty aluminum case. Requires full time
          battery pack. Does not include switch harness
          or battery pack.     
      131. For G-45,62 and GT 74,80 twin .................................................................................................. $124.95
      132. For G-62 With broken magneto coil mount  ................................................................................. $134.95
      134. For G-26 w/magneto ................................................................................................................... $124.95
      135. For G-38 (CHXL)............................................................................................................................ $134.95
          The G-38 system includes the spark coil built
           into the Ignition module.
      148. For Zenoah G-20 and G-26 w/electronic ignition, (CHXL) ................................................................  $94.95
              The package for electronic ignition equipped models
               includes new ignition module, sensor,and bracket.
       150 Zenoah G20 and G26 w/electronic ignition, (CHXL) PNP ................................................................$79.95
      Ignition only with Zenoah connector, (uses Zenoah sensor)
     
    
  FUJI IGNITION PACKAGES
      213. For Fuji 43,50,64 w/electronic ignition  ....................................................................................... $105.95
      113. For Fuji BT 86 w/magneto ..........................................................................................................$145.95
      114. For Fuji BT 64 w/magneto .............................................................................................................. $124.95
      115. For Fuji BT 50 w/magneto .............................................................................................................. $124.95

  3-W and DA IGNITION PACKAGES
      227. For DA and 3W singles .....................................................................................................................$79.95
      241. For DA and 3W twins .......................................................................................................................$99.95
        89. Timing kit for above, Machined billet ..................................................................................................$29.95
        21. Universal timing kit for above .............................................................................................................$14.95

  EVO IGNITION PACKAGES
    212. EVO 26 ..............................................................................................................................................$104.95
    214 EVO 35, 40, 45, 50, 80 58 ................................................................................................................$99.95
    215 EVO 116, 152 .....................................................................................................................................$119.95

  JUMP START SYSTEMS
           Complete, includes battery box and switch.  Requires 4 AA alkaline batteries
           (not included).  Your engine must have a working
           magneto and will run on the magneto after it is started. Easy hand starts with no kick back!
           102. Jump start for Zenoah G-45, 62 and GT-80  ............................................................................ $59.95

  WEED TRIMMER CONVERSIONS
            Complete ignition conversion for some weed trimmer engines.  Includes
            ignition, prop hub nut, washer, timing clamp and pulse switch.  Does not

            include switch harness, battery pack, spark plug, engine mount or muffler
            Or the Syncro Spark Module. These small gas burners work fine with fixed
            timing. They are low compression and will not normally kick back.
            97. McCulloch 28/32-CC trimmer or leaf blower ............................................................................... $119.95
            98. Roybi 31 CC . ............................................................................................................................. $119.95
            99. Homelite 25 and 30 cc ................................................................................................................. $119.95
                 Add $4.95 for adapter shaft for short crankshaft engines.
            103. Timing kit for the above trimmer engines.  ................................................................................. $39.95
                    Does not include ignition system. Includes prop hub, magnet,
                    timing clamp, pulse switch, prop nut and washer
             105. Motor Mount for McCulloch or Homelite ............................................................................... $11.95
             
        LABOR FOR OTHER ENGINES
    107. Labor for us to set up your McCulloch , Ryobi or
                    Homelite engine ........................................................................................................................... $50.00
    121 Install single ignition system .....................................................................................................................$45.00
    106 Install twin ignition system .......................................................................................................................$55.00
    60 Make run service, $50.00/hr. minimum $35.00

  MISCELLANEOUS PARTS
         4. External Syncro Spark Computer timing module. Can be used
             with all older C.H. Ignition systems pix ................................................................................................ $29.95
             The external Timing module plugs in between your pulse
              switch and Ignition system. Timing control linkage is removed
              and timing plate locked so it will not move.
         68.  C.H. Ignition module high voltage board built and tested
                (build your own ignition).   Does not include spark coil ..................................................................... $39.95
        152. Compression shim for Saito 150 & 180 single ................................................................................... $5.00   
         14. Three pin Deans plug set .................................................................................................................... $1.50
         15. Deans charge plug set ........................................................................................................................ $2.00
         19. Heavy duty system switch ................................................................................................................. $19.95  Overstock special $9.95
         47. Ignition coil -     Heavy Duty, no plug wire ......................................................................................... $22.95
         48. Spark plug lead, resistor,  per foot ..................................................................................................... $2.00   Overstock Special .50/ft
         49. CHXL ignition switch .........................................................................................................................$9.95   Overstock special  $3.95
         50. Spark plug lead, non resistor,  per foot ............................................................................................... $2.00
         78. Shielded plug lead with billet 10 mm cap............................................................................................$24.95
         11. Shielded plug lead with rubber boot, 14mm ........................................................................................ $9.95
          53. Rubber boot and terminal only .......................................................................................................... $3.00
         54. Ignition and pulse switch tester NEW...................................................................................... ...... $21.95
         57. Radio operated switch NEW .........................................................................................................$21.95
                 Add $5.00 for jumpers for different type plugs
         56.Mini Tachometer NEW ..................................................................................................................$21.95
                  Add $5.00 for appropriate Y connector
         42. Magnet, selenium cobalt 8, 1/8 X 1/8 ................................................................................................. $2.50
           1. Pulse switch in tube with Deans, 5/16 diam ......................................................................................... $7.95
           3. Pulse switch, flat chip, with leads and Deans ....................................................................................... $7.95
              All the above pulse switches are available with Futaba plugs         
              for the same price.
          21. Universal timing kit, includes clamp, pulse switch and magnet.
              Fits many of the two and four stroke glow engine .60 to 1.80 ignitions
          125. or 128. ......................................................................................................................................... $14.95  

   FULLY SHIELDED STAINLESS STEEL SPAR PLUG CAPS -  NEW
      For upgrade or repair.  Instructions
         278      CHRCEXL Shielded Cap & Lead 14mm X 5/8"......................................................................... $17.95
         277    "        "        14MM x 3/4" ..............................................................................................................$17.95
         276           "             "                  "     10mm ............................................................................................ $17.95
         280. fits NGK CM6 10mm or Denso U20M-U ...................................................................................$12.95
         281. fits 14mm 3/4" hex Gasket NGK BMR 6A or BPMR6A...................................................................$12.95
         282. fits 14mm 5/8" hex Taper seat type NGK BPMR 6F, Champ RDJ6J or RDJ7J ................................$12.95
         110. CHXL 1/4 X 32 ............................................................................................................................... $9.95
         111.  Rim Fire 1/4X32 American made  .............................................................................................. $17.95
         5.  NGK CM-6 I0mm Spark plug pix ....................................................................................................... $8.50
         6.  NGK-BPMP-6-A, 14mm, fits most big gas burners ............................................................................. $3.95
         7.  NGK-BMR-6-A, 14 mm, fits G23&G38 ............................................................................................. $3.95
        16. NGK-BPMR-6-F..................................................... ..........................................................................  $4.95
          37.  NGK CMR7H, for Zenoah G26 w/mag ............................................................................................. $3.95
        69. Spark plug Adapter, l4mm to 10 mm ..................................................................................................... $9.95
        75. Spark plug, Adapter, 14mm to 1/4x32 ................................................................................................ $12.95
    120. HD Ignition switch, Fut, JR, Hi-Tec, Airt & Airt-Z .................................................................................. $7.95
       
 BATTERY PACKS
      104. 900ma Nimh with lead and connector ................................................................................................. $16.95
        39. 1650ma Nimh with leads and connector .............................................................................................. $21.95
      
ENGINE PARTS
       61. Single bolt prop adapter for six bolt prop hub as used
            by A& M Walker, Planes plug eaglet and  others. 3/8" .......................................................................... $21.95
        62. Single bolt adapter for above engines 7/16" ......................................................................................... $23.95
        64. Delron timing plate for A&M 2.6 or 3.2 .............................................................................................. $14.95
        65. Delron timing plate for A&M 4.2 or 5.8 .............................................................................................. $17.95
        51. Gasoline conversion kits for ST 3000 & 3250 ..................................................................................... $64.95
        52. Gas conversion kit for ST 3000 & 3250 less carb ............................................................................... $24.95
            Above kits do not include any ignition parts.         
            Large glo engines must first be converted
           to Ignition before converting to gas fuel.
        24. HD DSC switch for radio or ignition. (Fut, JR, Airt-Z) ......................................................................... $15.95
        
Back